clear
Sunday May 3rd, 2015 6:58PM

Promises of easier nuclear construction fall short

By The Associated Press
WAYNESBORO, Ga. (AP) -- The U.S. nuclear industry has started building its first new plants in decades using prefabricated Lego-like blocks meant to save time and money and revive the once promising energy source.<br /> <br /> So far, it's not working.<br /> <br /> Quality and cost problems have cropped up again, raising questions about whether nuclear power will ever be able to compete with other electricity sources. The first two reactors built after a 16-year lull, Southern Co.'s Vogtle plant in Georgia and SCANA Corp.'s VC Summer plant in South Carolina, are being assembled in large modules. Large chunks of the modules are built off-site, in an effort to improve quality and avoid the chronic cost overruns that all but killed the nuclear industry when the first wave of plants was being built in the 1960s and 1970s.<br /> <br /> Analysts say engineers created designs that were hard or impossible to make, according to interviews and regulatory filings reviewed by The Associated Press. The factory in Louisiana that constructed the prefabricated sections struggled to meet strict quality rules. Utility companies got early warnings but proved unable to avoid the problems. Now the firms leading the project are phasing out the Louisiana factory for work on the biggest modules and contracting with new manufacturers.<br /> <br /> Few power companies are building brand-new nuclear plants right now because gas-fired plants are so cheap by comparison. But if construction costs can be controlled, the nuclear industry might have a long-term chance. Future gas prices are always uncertain, and stricter U.S. pollution rules could make nuclear plants more attractive since they produce no greenhouse gasses. The difficulties producing modules are one factor that caused schedules to slide. The first of the two new reactors at each site in Georgia and South Carolina were supposed to be operating in 2016, but that timetable has now been pushed into 2017 or early 2018. In Georgia, Southern Co. expects to spend $646 million more than the originally budgeted $6.1 billion on its share of the project.<br /> <br /> Joseph "Buzz" Miller, a Southern Co. executive tasked with building the nuclear plant in Georgia, thinks building in modules can still work, despite the recent trouble. "Has it for the first units resulted in a lot of time savings? No," he said. "But does it have promise? Yes."<br /> <br /> Years ago, large workforces built nuclear power plants part by part. Using so much labor was expensive and difficult to manage. It increased the odds a work crew might make a mistake or fall behind schedule.<br /> <br /> This time, the industry settled on a different technique. The utilities in Georgia and South Carolina purchased power plants that use the AP1000 reactor designed by Westinghouse Electric Co. Its modules can weigh hundreds of tons and dwarf buildings.<br /> <br /> The Shaw Modular Solutions factory in Lake Charles, Louisiana, was to produce large, prefabricated chunks of the plants.<br /> <br /> "You can build these components in a closed environment," Edward Day VI, an executive vice president for Southern Co., told regulators in a 2008 hearing. "Your productivity goes way up."<br /> <br /> The large sections are shipped to Plant Vogtle in eastern Georgia and the Summer generation station in South Carolina, where workers inspect them, weld them into large modules, then hoist them into place with massive derricks.<br /> <br /> A nuclear engineer working for Georgia's utility regulators, William Jacobs Jr., warned in December 2010 that the Louisiana factory had experienced delays due to quality assurance, design and fabrication problems. He called it a "significant concern."<br /> <br /> Inspectors for the U.S. Nuclear Regulatory Commission halted their first review of the plant the following month, saying it was not ready for in-depth scrutiny. Follow-up inspections found more issues with the plant's quality assurance programs. NRC officials proposed a $36,400 fine against The Shaw Group for firing a quality insurance supervisor elsewhere in its company who warned a potentially faulty part may have been shipped to a project in New Mexico. The fine was dropped after the company agreed to changes. The agency also said workers at the Lake Charles facility feared raising safety and quality concerns to their supervisors.<br /> <br /> The NRC concluded that a welder at the factory took a qualification test for another worker in 2010, and that a supervisor knew but did not report it.<br /> <br /> "I think the Lake Charles facility is just on a learning curve that they can't seem to get on top of," said Anthony James, who monitors the South Carolina nuclear project for the South Carolina Office of Regulatory Staff, which oversees utilities.<br /> <br /> Chicago Bridge & Iron Co. N.V. acquired The Shaw Group in February 2013. The new owners replaced top managers at the factory, adopted a less antagonistic stance toward inspectors and allowed Southern Co. and SCANA Corp. to conduct more oversight. CBI spokeswoman Gentry Brann refused interview requests.<br /> <br /> The factory is now sending partially completed modules directly to the construction site to be inspected and repaired under the careful watch of the utility companies.<br /> <br /> Going forward, Westinghouse and CB&I are phasing out the Lake Charles factory and hiring firms in Oregon, Florida and Virginia to build the largest modules, Southern Co. spokesman Brian Green said. The Lake Charles factory will still produce smaller pieces such as piping, valves or instrumentation.<br />
© Copyright 2015 AccessNorthGa.com
All rights reserved. This material may not be published, broadcast, rewritten, or redistributed without permission.
Judge denies motions to move, delay Tsarnaev trial
Lawyers for Boston Marathon bombing suspect Dzhokhar Tsarnaev asked a federal appeals court Wednesday to overturn a judge's decision to not move his upcoming trial out of state.
10:02PM ( 4 months ago )
High court to adopt electronic filing of cases
The Supreme Court is belatedly developing an electronic filing system similar to those used in courts around the country, Chief Justice John Roberts said Wednesday in his annual end-of-year report.
7:57PM ( 4 months ago )
Storm brings snow, cold to West for New Year's
A blustery winter storm dumped snow and ice across the West on Wednesday, making driving treacherous in the mountains from California to the Rockies and forcing residents and party-goers in some usually sun-soaked cities to bundle up for a frosty New Year's.
5:19PM ( 4 months ago )
U.S. News
State DOT awards $48M contract for NE Ga. road project
The state Department of Transportation has awarded a $47.8 million contract for nine miles of work on a northeast Georgia road.
9:37AM ( 4 months ago )
Business News
Grass fire impacts rush hour traffic on 985
Rush hour traffic on I-985 was slowed by a grass fire Wednesay afternoon with one lane closed while firefighters fought the blaze.
10:19PM ( 4 months ago )
Hall County conviction, sentencing to be reviewed by SCOGA
The State Supreme Court has agreed to hear the appeal of a Hall County man when they reconvene in January.
2:37PM ( 4 months ago )
Maysville man dies from Banks County wreck
The Georgia State Patrol reports that alcohol and/or drugs were factors a single-vehicle wreck that claimed the life of a Maysville man in Banks County Tuesday night.
11:07AM ( 4 months ago )
Local/State News
Obama again avoids calling 1915 Armenian killings 'genocide'
WASHINGTON (AP) — President Barack Obama will once again stop short of calling the 1915 massacre of Armenians a genocide, prompting anger and disappointment from those who have been pushing him to ful...
1:00PM ( 1 week ago )
Ex-NFL star Hernandez convicted of murder, sentenced to life
FALL RIVER, Mass. (AP) — Former New England Patriots star Aaron Hernandez was convicted of first-degree murder and sentenced to life in prison Wednesday for a deadly late-night shooting, sealing the d...
8:54PM ( 2 weeks ago )
Clinton kicks off 2016 campaign online, heads next to Iowa
WASHINGTON (AP) — Hillary Rodham Clinton jumped back into presidential politics on Sunday, making a much-awaited announcement she will again seek the White House with a promise to serve as the "champi...
7:56PM ( 2 weeks ago )
Hall, White, Jefferson schools recognized nationally for use of technology
Three school districts in northeast Georgia - Hall, White, and Jefferson - have received national recognition for their use use of innovative technologies. They earned top spots in the Center for Digital Education's and the National School Boards Association's 10th annual Digital School Districts Survey.
By Staff
1:00PM ( 3 weeks ago )
US Capitol lockdown lifted after man fatally shoots himself
WASHINGTON (AP) — A precautionary lockdown of the U.S. Capitol was lifted after about two hours Saturday following a suicide by a man carrying a protest sign.The man died after shooting himself on the...
6:15PM ( 3 weeks ago )