Saturday October 10th, 2015 3:49PM

13 GM traffic deaths are tied to a 57-cent part

By The Associated Press
WASHINGTON (AP) -- The fix for a faulty ignition switch linked to 13 traffic deaths would have cost just 57 cents, members of Congress said Tuesday as they demanded answers from General Motors' new CEO on why the automaker took 10 years to recall cars with the defect.

At a hearing on Capitol Hill before a House subcommittee, GM's Mary Barra acknowledged under often testy questioning that the company took too long to act. She promised changes at GM that would prevent such a lapse from happening again.

"If there's a safety issue, we're going to make the right change and accept that," said Barra, who became CEO in January and almost immediately found herself thrust into one of the biggest product safety crises Detroit has ever seen.

But as relatives of the crash victims looked on intently, she admitted that she didn't know why it took years for the dangerous defect to be announced. And she deflected many questions about what went wrong, saying an internal investigation is under way.

Since February, GM has recalled 2.6 million cars - mostly Chevrolet Cobalts and Saturn Ions - over the faulty switch, which can cause the engine to cut off in traffic, disabling the power steering, power brakes and air bags and making it difficult to control the vehicle. The automaker said new switches should be available starting April 7.

Barra was firm, calm and polite throughout the proceedings. But she struggled at times to answer lawmakers' pointed questions, particularly about why GM used the switch when it knew the part didn't meet its own specifications.

When she tried to draw a distinction between parts that didn't meet specifications and those that were defective and dangerous, Rep. Joe Barton, R-Texas, shot back: "What you just answered is gobbledygook."

She also announced that GM has hired Kenneth Feinberg - who handled the fund for the victims of 9/11, the Boston Marathon bombing and the BP oil spill - to explore ways to compensate victims of accidents in the GM cars. Barra stopped short of saying GM would establish such a fund.

Some of the questioners appeared surprised that Barra hadn't reviewed the tens of thousands of pages of documents that GM submitted to the committee, and that she was unaware of some decision-making processes at the company.

Rep. Diana DeGette, D-Colo., held up a switch for one of the cars and said a small spring inside it failed to provide enough force, causing engines to turn off when they went over a bump.

DeGette showed how easy it was for a light set of car keys to move the ignition out of the "run" position.

GM has said that in 2005, company engineers proposed solutions to the switch problem, but the automaker concluded that none represented "an acceptable business case."

"Documents provided by GM show that this unacceptable cost increase was only 57 cents," DeGette said.

The 57 cents is just the cost of the replacement switch. The figure does not include the labor costs involved in installing the new part.

Barra testified that the fix to the switch, if undertaken in 2007, would have cost GM about $100 million, compared with "substantially" more now.

Under questioning, she said the automaker's decision not to make the fix because of cost considerations was "disturbing" and unacceptable, and she assured members of Congress that that kind of thinking represents the old General Motors, and "that is not how GM does business" today.

"I think we in the past had more of a cost culture," Barra said, adding that it is moving toward a more customer-focused culture.

Rep. Tim Murphy, R-Pa., chairman of the House Energy and Commerce Subcommittee on Oversight and Investigations, read from an e-mail exchange between GM employees and those at Delphi, which made the switch. One said that the Cobalt is "blowing up in their face in regards to the car turning off."

Murphy asked why, if the problem was so big, GM didn't replace all of them in cars already on the road.

"Clearly there were a lot of things happening" at that time, Barra said.

In his prepared remarks, David Friedman, head of the National Highway Traffic Safety Administration, pointed the finger at GM, saying the automaker had information last decade that could have led to a recall, but shared it only last month.

Rep. Henry Waxman, D-Calif., said that House Energy and Commerce Committee staff members found 133 warranty claims filed with GM over 10 years detailing customer complaints of sudden engine stalling when they drove over a bump or brushed keys with their knees.

The claims were filed between June 2003 and June 2012.

Waxman said that because GM didn't undertake a simple fix when it learned of the problem, "at least a dozen people have died in defective GM vehicles."

Some current GM car owners and relatives of those who died in crashes were also in Washington seeking answers. The group attended the hearing after holding a news conference demanding action against GM and stiffer legislation.

Owners of the recalled cars can ask dealers for a loaner vehicle while waiting for the replacement part. Barra said GM has provided more than 13,000 loaners.
© Copyright 2015
All rights reserved. This material may not be published, broadcast, rewritten, or redistributed without permission.
Judge denies motions to move, delay Tsarnaev trial
Lawyers for Boston Marathon bombing suspect Dzhokhar Tsarnaev asked a federal appeals court Wednesday to overturn a judge's decision to not move his upcoming trial out of state.
10:02PM ( 9 months ago )
High court to adopt electronic filing of cases
The Supreme Court is belatedly developing an electronic filing system similar to those used in courts around the country, Chief Justice John Roberts said Wednesday in his annual end-of-year report.
7:57PM ( 9 months ago )
Storm brings snow, cold to West for New Year's
A blustery winter storm dumped snow and ice across the West on Wednesday, making driving treacherous in the mountains from California to the Rockies and forcing residents and party-goers in some usually sun-soaked cities to bundle up for a frosty New Year's.
5:19PM ( 9 months ago )
U.S. News
State DOT awards $48M contract for NE Ga. road project
The state Department of Transportation has awarded a $47.8 million contract for nine miles of work on a northeast Georgia road.
9:37AM ( 9 months ago )
Business News
Grass fire impacts rush hour traffic on 985
Rush hour traffic on I-985 was slowed by a grass fire Wednesay afternoon with one lane closed while firefighters fought the blaze.
10:19PM ( 9 months ago )
Hall County conviction, sentencing to be reviewed by SCOGA
The State Supreme Court has agreed to hear the appeal of a Hall County man when they reconvene in January.
2:37PM ( 9 months ago )
Maysville man dies from Banks County wreck
The Georgia State Patrol reports that alcohol and/or drugs were factors a single-vehicle wreck that claimed the life of a Maysville man in Banks County Tuesday night.
11:07AM ( 9 months ago )
Local/State News
GOP leader regrets talk to white supremacists; party leaders rally around him
House Republican leaders rallied around one of their own, Whip Steve Scalise, on Tuesday after he said he regrets speaking 12 years ago to a white supremacist organization and condemns the views of such groups.
6:08PM ( 9 months ago )
Conviction of Putin foe sets off protest in Moscow
President Vladimir Putin's chief political foe was convicted along with his brother on Tuesday in a fraud case widely seen as a vendetta by the Kremlin, triggering one of Russia's boldest anti-government demonstrations in years.
6:03PM ( 9 months ago )
More Georgians signing up for health insurance
A federal report says more Georgians have selected health insurance plans through a federally facilitated marketplace.
4:16PM ( 9 months ago )
UN is next stop for Obama after success with Iran, pope; top issues are IS, Syria, Russia
NEW YORK (AP) — Fresh from successes on Iran and with the pope, President Barack Obama still carried heavy burdens into critical meetings this week at the U.N. General Assembly.They include the threat...
3:31PM ( 1 week ago )
Stunning Congress, House Speaker Boehner announces plans to resign; tea party declares victory
WASHINGTON (AP) — Plunging Congress into deeper turmoil, House Speaker John Boehner abruptly announced his resignation Friday, shutting down a tea party drive to depose the nation's highest-ranking Re...
6:14PM ( 2 weeks ago )
Tornado heavily damages 10 homes but causes no injuries on island in South Carolina
JOHNS ISLAND, S.C. (AP) — A tornado quickly blew through a neighborhood on the South Carolina coast early Friday and blew out windows, knocked down trees and heavily damaged ten homes.The tornado touc...
5:08PM ( 2 weeks ago )
Caterpillar says it may cut more than 10,000 jobs by 2018, lowers 2015 revenue expectation
Caterpillar is planning another round of job cuts that could exceed 10,000 people through 2018, as the construction and mining equipment maker adjusts to downturns in key markets.That could amount to...
10:06AM ( 2 weeks ago )
Escaped tarantula grounds Atlanta-bound flight in Baltimore
An eight-legged creature that escaped in the cargo hold of a passenger flight from Baltimore-Washington International Airport to Atlanta's Hartsfield-Jackson International grounded the plane and sent passengers onto another flight.
By The Associated Press
9:06AM ( 2 weeks ago )