Tuesday December 1st, 2015 8:40PM

Safety board faults key device in BP oil spill

By The Associated Press
WASHINGTON (AP) -- A federal board investigation into the 2010 BP oil spill concludes that a last-ditch safety device on the underwater well had multiple failures, wasn't tested properly and still poses a risk for many rigs drilling today.<br /> <br /> The report issued Thursday by the U.S. Chemical Safety Board zeroes in on what went wrong with the blowout preventer and blames bad management and operations. They found faulty wiring in two places, a dead battery and a bent pipe in the hulking device. And that, they said, led to the dumping of 172 million gallons of oil into the Gulf of Mexico and the nation's worst offshore oil disaster.<br /> <br /> Investigators have long known that the device failed. But "The problems with this blowout preventer were worse than we understood," safety board managing director Daniel Horowitz said in an interview. "And there are still hazards out there that need to be improved if we are to prevent this from happening again."<br /> <br /> The massive spill followed an explosion that killed 11 workers at the Deepwater Horizon drilling rig, about 50 miles off the Louisiana coast.<br /> <br /> Massive blowout preventers are anchored to the top of underwater wells. In an emergency, the devices use multiple mechanisms - including clamps and shears - to try to choke off the oil flowing up from a pipe and disconnect the rig from the well. They can operate automatically when pressure or electricity is cut off or manually.<br /> <br /> The 9-year-old one that failed was nearly 57 feet tall and weighed about 400 tons.<br /> <br /> Robert Bea, a professor of engineering and expert in oil pipelines at the University of California Berkeley, praised the report and said blowout preventers are like cruise ship lifeboats, used only in last resort but crucial. In this case the blowout preventers "are deeply flawed, they've got holes," said Bea, who was not involved in the new study.<br /> <br /> Kevin Ewing, a Washington attorney who represents many oil drilling interests, said well operators have improved their techniques. He cautioned against broad indictments on the safety of currently operating blowout preventers.<br /> <br /> Various investigations have found that the cause of the initial explosion involved multiple screw-ups with cement, drilling mud, fluid pressure, botched tests, management problems and poor decisions. The blowout preventer sealed the well temporarily, but then it failed and that caused the massive spill, the new 166-page report found.<br /> <br /> The report faulted the rig operators. The problem, said safety board investigator Mary Beth Mulcahy, was that well owner BP and rig operator Transocean didn't test the blowout preventer's individual safety systems. They just tested the device as a whole. It turned out there were two sets of faulty wiring that caused problems and a dead battery.<br /> <br /> Mulcahy said individual tests were suggested by the preventer's manufacturer but the companies instead followed a standard set by the industry.<br /> <br /> The safety board also found that the drill pipe bent far earlier in the accident and from a different cause than determined by a presidential oil spill commission. That failure is also connected to a problem with the blowout preventers, investigators said.<br /> <br /> The board said the same device design is being used on at least 30 rigs worldwide and some general problems with operations and testing could affect other types of preventers.<br /> <br /> Donald Boesch, a University of Maryland professor who was on the presidential oil spill commission, agreed with the latest investigation. He said the chemical safety board was able to do what his board didn't do, a hands-on testing of the device.<br /> <br /> The two companies involved in rig operations blamed each other. BP spokesman Geoff Morrell said all of the evidence "demonstrates that Transocean owned the rig's blowout preventer and was responsible for its maintenance."<br /> <br /> Transocean spokesman Brian Kennedy noted that BP pleaded guilty to 12 felony counts from the accident while Transocean did to only one misdemeanor violation of the Clean Water Act. He also said the blowout preventer "had been tested successfully in accordance with regulatory requirements and activated as intended at the time of the incident, but was unable to seal the well because immense pressure buckled the drill pipe."<br />
© Copyright 2015 AccessWDUN.com
All rights reserved. This material may not be published, broadcast, rewritten, or redistributed without permission.
Judge denies motions to move, delay Tsarnaev trial
Lawyers for Boston Marathon bombing suspect Dzhokhar Tsarnaev asked a federal appeals court Wednesday to overturn a judge's decision to not move his upcoming trial out of state.
10:02PM ( 11 months ago )
High court to adopt electronic filing of cases
The Supreme Court is belatedly developing an electronic filing system similar to those used in courts around the country, Chief Justice John Roberts said Wednesday in his annual end-of-year report.
7:57PM ( 11 months ago )
Storm brings snow, cold to West for New Year's
A blustery winter storm dumped snow and ice across the West on Wednesday, making driving treacherous in the mountains from California to the Rockies and forcing residents and party-goers in some usually sun-soaked cities to bundle up for a frosty New Year's.
5:19PM ( 11 months ago )
U.S. News
State DOT awards $48M contract for NE Ga. road project
The state Department of Transportation has awarded a $47.8 million contract for nine miles of work on a northeast Georgia road.
9:37AM ( 11 months ago )
Business News
Grass fire impacts rush hour traffic on 985
Rush hour traffic on I-985 was slowed by a grass fire Wednesay afternoon with one lane closed while firefighters fought the blaze.
10:19PM ( 11 months ago )
Hall County conviction, sentencing to be reviewed by SCOGA
The State Supreme Court has agreed to hear the appeal of a Hall County man when they reconvene in January.
2:37PM ( 11 months ago )
Maysville man dies from Banks County wreck
The Georgia State Patrol reports that alcohol and/or drugs were factors a single-vehicle wreck that claimed the life of a Maysville man in Banks County Tuesday night.
11:07AM ( 11 months ago )
Local/State News
White House offers governors info on refugees in their states after Syrian migrants uproar
WASHINGTON (AP) — The White House is proposing to offer governors individualized reports about refugees in their states.White House chief of staff Denis McDonough says in letters to all 50 governors t...
9:08PM ( 23 hours ago )
Standoff at Planned Parenthood ends with suspect's arrest; 3 killed, 9 wounded
COLORADO SPRINGS, Colo. (AP) — A gunman who opened fire inside a Planned Parenthood clinic was arrested Friday after engaging in gun battles with authorities during an hourslong standoff that killed t...
1:13AM ( 3 days ago )
White House undergoes Thanksgiving Day lockdown after man draped in American flag jumps fence
WASHINGTON (AP) — A man draped in an American flag climbed over the fence at the White House on Thursday, prompting a lockdown as the first family celebrated Thanksgiving.The man was immediately appre...
10:11PM ( 4 days ago )
Obama grants reprieve to turkeys 'Honest' and 'Abe' during White House ceremony
WASHINGTON (AP) — President Barack Obama spared two turkeys named for one of the nation's most admired presidents, continuing a White House tradition that provides a refreshing sense of amusement and...
9:18PM ( 5 days ago )
The Latest: UN Security Council strongly condemns 'horrifying' attack in Mali, urges probe
BAMAKO, Mali (AP) — The latest on the attack on a hotel in the Malian capital of Bamako. (All times local):___4:55 a.m.The U.N. Security Council is condemning "the horrifying terrorist attack" at the...
10:58PM ( 1 week ago )